903951 MATERIAL SAFETY DATA SHEET: USA
MEDICAL EMERGENCIES ONLY (24 Hour Service): 1-800-328-0026
Medical Calls from Outside of the USA: 1-651-222-5352
Ecolab Vehicle Care Division
Ecolab Center St. Paul MN 55102
Product Information: 1-877-ECOWASH Issue Date: September 30, 2003
===========================================================================
1.0 IDENTIFICATION /
1.1 Product Name: CWX 6611
1.2 Product Type: Liquid Acidic Vehicle Wash Paint Sealer
1.3 Hazard Rating: Health: 3 Fire: 0 Reactivity: 0
---------------------------------------------------------------------------
Substances Subject to SARA 313 Reporting Are Indicated by "#"
---------------------------------------------------------------------------
2.0 HAZARDOUS COMPONENTS / (in mg/m3)
CAS No. % PEL TWA
2.1 Phosphoric acid 7664-38-2 5 1 1*
*ACGIH STEL = 3
2.2 Quaternary ammonium chloride compounds mixture 5-20 No No
2.3 Nonionic surfactants mixture 1-5 No No
---------------------------------------------------------------------------
STEL = ACGIH short term exp. limit (15 min) PEL = OSHA 8 hr ave in air
TWA = ACGIH 8 hr average C = ceiling limit in air, do not exceed
---------------------------------------------------------------------------
3.0 PHYSICAL DATA /
3.1 Appearance: Clear colorless liquid; pina colada fragrance
3.2 Solubility in Water: Mixes with water in all proportions
3.3 pH: 2.5-3.5 (at 100%)
3.4 Initial Boiling Point: > 212 deg F / 100 deg C
3.5 Specific Gravity: 1.026 @ 68 deg F / 20 deg C
---------------------------------------------------------------------------
4.0 FIRE AND EXPLOSION DATA /
4.1 Special Fire Hazards: None, does not support combustion.
4.2 Fire Fighting Methods: Use method appropriate for surrounding fire.
---------------------------------------------------------------------------
5.0 REACTIVITY DATA /
5.1 Stability: Stable under normal conditions of use and handling.
5.2 Conditions to Avoid: Reacts with metals and vigorously with alkalis.
Mixing with chlorinated products causes chlorine gas and hazardous
vapors. Mix only with water. Keep from freezing.
---------------------------------------------------------------------------
6.0 SPILL OR LEAK PROCEDURES / WEAR PROPER PROTECTIVE EQUIPMENT
6.1 Cleanup: Dike or dam large spills. Pump to containers or soak up
on inert absorbent. Flush residue or small spills to sanitary sewer.
6.2 Waste Disposal: Consult state/local authority for limits on chemical
waste disposal. Unused product is RCRA corrosive (D002).
===========================================================================
7.0 HEALTH HAZARD DATA / DANGER
7.1 Effects of Overexposure to Concentrate:
Eyes: Corrosive. Causes chemical burns. May cause blindness.
Skin: Corrosive. Causes chemical burns.
If Swallowed: Harmful or fatal. Causes chemical burns of mouth,
throat and stomach.
If Inhaled: Vapors or mist cause irritation, including a burning
taste, sneezing, coughing and difficulty breathing. People with
asthma or other lung problems may be more affected.
---------------------------------------------------------------------------
8.0 FIRST AID /
8.1 Eyes: Flush at once with cool running water. Remove contact lenses
and continue flushing for 15 minutes, holding eyelids apart so as to
rinse entire eye. SEEK MEDICAL ATTENTION IMMEDIATELY.
8.2 Skin: Immediately flush skin with plenty of cool running water for
at least 15 minutes while removing contaminated clothing and shoes.
Discard or wash before reuse.
8.3 If Swallowed: Rinse mouth at once; then drink 1 or 2 large glasses
of water. DO NOT induce vomiting. NEVER give anything by mouth to
an unconscious person.
8.4 If Inhaled: Immediately move to fresh air.
IMMEDIATELY CALL THE MEDICAL EMERGENCY NUMBER, 1-800-328-0026,
A POISON CONTROL CENTER, OR A PHYSICIAN
---------------------------------------------------------------------------
9.0 PROTECTIVE MEASURES /
9.1 FOR CONCENTRATE:
Eyes: Wear chemical splash goggles. For continued or severe
exposure wear a face shield over the goggles.
Skin: Wear any impervious gloves, other protective equipment as
necessary to prevent skin contact.
Respiratory: Avoid breathing mists or vapors of this product.
Ventilate to maintain air levels below exposure limits.
Note: Provide access to emergency eye wash and shower.
---------------------------------------------------------------------------
10.0 ADDITIONAL INFORMATION /
10.1 Purpose of 9/30/2003 issue: Formulation change. Replaces June 13, 200
issue.
KEEP OUT OF REACH OF CHILDREN
The above information is believed to be correct with respect to the
formula used to manufacture the product in the country of origin. As data,
standards, and regulations change, and conditions of use and handling are
beyond our control, NO WARRANTY, EXPRESS OR IMPLIED, IS MADE AS TO THE
COMPLETENESS OR CONTINUING ACCURACY OF THIS INFORMATION.
|