939095 MATERIAL SAFETY DATA SHEET
MEDICAL EMERGENCIES ONLY (24 Hour Service): 1-800-328-0026
Medical Calls from Outside of the USA: 1-651-222-5352
Ecolab Vehicle Care Division
Ecolab Center St. Paul MN 55102
Product Information: 1-877-ECOWASH Issue Date: May 18, 2001
==========================================================================
1.0 IDENTIFICATION /
1.1 Product Name: CWX 3600
1.2 Product Type: Liquid Alkaline Vehicle Wash Detergent
1.3 Hazard Rating: Health: 3 Fire: 0 Reactivity: 0
--------------------------------------------------------------------------
Substances Subject to SARA 313 Reporting Are Indicated by "#"
--------------------------------------------------------------------------
2.0 HAZARDOUS COMPONENTS / (in mg/m3)
CAS No. % PEL TWA
2.1 Potassium hydroxide (caustic potash) 1310-58-3 2 No 2C
2.2 Sodium metasilicate 6834-92-0 1-5 No No
2.3 Sodium phosphate, tribasic 7758-29-4 4 No No
2.4 Chelating agent proprietary 1-5 No No
2.5 Nonionic and Anionic surfactants mixture 5-20 No No
--------------------------------------------------------------------------
STEL = ACGIH short term exp. limit (15 min) PEL = OSHA 8 hr ave in air
TWA = ACGIH 8 hr average C = ceiling limit in air, do not exceed
--------------------------------------------------------------------------
3.0 PHYSICAL DATA /
3.1 Appearance: Clear liquid; solvent-like odor
3.2 Solubility in Water: Mixes with water in all proportions
3.3 pH: 11.5 - 12.5 (1%)
3.4 Initial Boiling Point: > 212 deg F / 100 deg C
3.5 Specific Gravity: 1.166 @ 68 deg F / 20 deg C
--------------------------------------------------------------------------
4.0 FIRE AND EXPLOSION DATA /
4.1 Special Fire Hazards: None, does not support combustion.
4.2 Fire Fighting Methods: Use method appropriate for surrounding fire.
--------------------------------------------------------------------------
5.0 REACTIVITY DATA /
5.1 Stability: Stable under normal conditions of use and handling.
5.2 Conditions to Avoid: Reacts with acids and soft metals i.e. aluminum
or zinc, producing flammable hydrogen gas. Mix only with water.
--------------------------------------------------------------------------
6.0 SPILL OR LEAK PROCEDURES / WEAR PROPER PROTECTIVE EQUIPMENT
6.1 Cleanup: Dike or dam large spills. Pump to containers or soak up
on inert absorbent. Flush residue or small spills to sanitary sewer.
6.2 Waste Disposal: Consult state/local authority for limits on chemical
waste disposal. Unused product is RCRA corrosive (D002).
==========================================================================
7.0 HEALTH HAZARD DATA / DANGER
7.1 Effects of Overexposure to Concentrate:
Eyes: Causes severe irritation. Untreated contact may cause
chemical burns or permanent damage.
Skin: Causes moderate to severe irritation.
If Swallowed: May cause chemical burns of mouth, throat and stomach.
If Inhaled: Mists may cause irritation to mouth, throat, or lungs.
-------------------------------------------------------------------------
8.0 FIRST AID /
8.1 Eyes: Flush with cool running water. Remove contact lenses and
continue flushing for 15 minutes. Get medical attention.
8.2 Skin: Flush skin with water; wash with soap and water. Remove
and wash contaminated clothing before reuse.
8.3 If Swallowed: Rinse mouth; then drink 1 or 2 large glasses of
water. DO NOT induce vomiting. NEVER give anything by mouth to
an unconscious person.
8.4 If Inhaled: Immediately move to fresh air.
IF IN EYES OR IF IRRITATION OR DISCOMFORT PERSIST, CALL A PHYSICIAN
--------------------------------------------------------------------------
9.0 PROTECTIVE MEASURES /
9.1 FOR CONCENTRATE:
Eyes: Wear chemical splash goggles. For continued or severe
exposure wear a face shield over the goggles.
Skin: Wear any industrial rubber glove, other protection as needed
to avoid skin contact.
Respiratory: Avoid breathing mists or vapors of this product.
--------------------------------------------------------------------------
10.0 ADDITIONAL INFORMATION /
10.1 DOT: CORROSIVE LIQUID, BASIC, INORGANIC, N.O.S.,(POTASSIUM HYDROXIDE,
SODIUM METASILICATE),8,UN3266,III
10.2 Purpose of 5/18/2001 issue: Revise Line 1.3.
Replaces September 20, 2000 issue.
KEEP OUT OF REACH OF CHILDREN
The above information is believed to be correct with respect to the
formula used to manufacture the product. As data, standards, and
regulations change, and conditions of use and handling are beyond our
control, NO WARRANTY, EXPRESS OR IMPLIED, IS MADE AS TO THE COMPLETENESS
OR CONTINUING ACCURACY OF THIS INFORMATION.
|